Repair Volkswagen Cars Manual

Home > Automotive > Volkswagen

Source: volkswagen.msk.ru
Topic: Volkswagen

Short Desciption:
Repair Manual, Suspension, Wheels, Brakes, Steering m.y. 1992-1996, ... Vehicles with manual transmission - Check clutch release bearing in slave cylinder ...

Content Inside:
Repair Volkswagen cars manual 10-1 Engine, removing and installing Special tools and equipment VAG 1921 Spring-clip Pliers VAG 1306 Drip tray 3277A Installation tool 3408 Engine support VAG 1383 A Engine/transmission jack G 000 100 Grease (for vehicles with manual transmission) VAG 1331 Torque wrench (5 to 50 Nm) VAG 1332 Torque wrench (40 to 200 Nm) Cable tie Remove engine/transmission assembly from below. CAUTION! Obtain radio code before disconnecting battery ground strap. Disconnect battery ground cable. Ignition must be switched OFF Always replace cable ties in original position. 10-2 Drain coolant Page 19-14 . Remove radiator and radiator cooling fan Page 19-22 . Remove ribbed belt Page 13-22 . Repair Manual, Suspension, Wheels, Brakes, Steering m.y. 1992-1996, Repair Group 40 Repair Manual, Suspension, Wheels, Steering from m.y. 1997, Repair Group 40 Detach hose from combi-valve at Air Cleaner upper section -arrow-. Remove intake manifold complete with intake manifold lower section and Throttle Valve Control Module Page 15-9 . Disconnect power steering lines from right engine support. Remove power steering pump with bracket and secure to body with wire (hoses remain connected). Remove front exhaust pipe Page 26-2 . Disconnect wiring from transmission, generator and starter and move out of the way. Disconnect all engine coolant, vacuum and breather hoses. 10-3 Vehicles with manual transmission: Pry off line/hose from slave cylinder on transmission. Vehicles with automatic transmission: Repair Manual, 4 Spd. Automatic Transmission 01P, Repair Group 37 Vehicles with A/C: Remove transverse support bolts -Aand -B-. Remove transverse support. Remove gearshift mechanism from transmission. Remove transmission shift cable. Observe additional information and removal instructions Page 1014 . 10-4 All vehicles: Remove axle shafts. Repair Manual, Suspension, Wheels, Brakes, Steering m.y. 1992-1996, Repair Group 40 Repair Manual, Suspension, Wheels, Steering from m.y. ...

Related PDF Files

Volkswagen unveiled the cleanest ever TDI engine

Topic: Volkswagen

so that the car can be driven without maintenance between two garage ... BlueTec is a joint project of the German car manufacturers Volkswagen, Audi ...

Volkswagen Recall Golf, Jetta and New Beetle With 2.0L Engine 1999-2001 ...

Topic: Volkswagen

Volkswagen subsequently. volunteered to recall these vehicles as well as similar 2000 ... notification letter from Volkswagen, owners should schedule ...